Issei Kato/Reuters
Safety inspectors looked over a 787 on Friday in Japan. The plane made an emergency landing after receiving a smoke alarm.
With 787 Dreamliners grounded around the world, Boeing is scrambling to devise a technical fix that would allow the planes to fly again soon, even as investigators in the United States and Japan are trying to figure out what caused the plane’s lithium-ion batteries to overheat.
Ray LaHood, the transportation secretary, made it clear on Friday that a rapid outcome was unlikely, saying that 787s would not be allowed to fly until the authorities were “1,000 percent sure” they were safe.
“Those planes aren’t flying now until we have a chance to examine the batteries,” Mr. LaHood told reporters. “That seems to be where the problem is.”
The Federal Aviation Administration on Wednesday took the rare step of grounding Boeing’s technologically advanced 787s after a plane in Japan made an emergency landing when one of its two lithium-ion batteries set off a smoke alarm in the cockpit. Last week at Boston’s Logan Airport, a battery ignited in a parked 787.
The last time the government grounded an entire fleet of airplanes was in 1979, after the crash of a McDonnell Douglas DC-10.
The grounding comes as the United States is going through a record stretch of safe commercial jet flying: It has been nearly four years since a fatal airline crash, with nearly three billion passengers flying in that period. The last airliner crash, near Buffalo, came after a quiet period of two and a half years, which suggests a declining crash rate.
Investigators in Japan said Friday that a possible explanation for the problems with the 787’s batteries was that they were overcharged — a hazard that has long been a concern for lithium-ion batteries. But how that could have happened to a plane that Boeing says has multiple systems to prevent such an event is still unclear.
Given the uncertainty, it will be hard for federal regulators to approve any corrective measures proposed by Boeing. To lift the grounding order, Boeing must demonstrate that any fix it puts in place would prevent similar episodes from happening.
The government’s approach, while prudent, worries industry officials who fear it does not provide a rapid exit for Boeing.
The F.A.A. typically sets a course of corrective action for airlines when it issues a safety directive. But in the case of the 787, the government’s order, called an emergency airworthiness directive, required that Boeing demonstrate that the batteries were safe but did not specify how.
While the government and the plane maker are cooperating, there are few precedents for the situation.
“Everyone wants the airplane back in the air quickly and safely,” said Mark V. Rosenker, a former chairman of the National Transportation Safety Board. “But I don’t believe there will be a corner cut to accomplish that. It will happen when all are confident they have a good solution that will contain a fire or a leak.”
Boeing engineers, Mr. Rosenker said, are working around the clock. “I bet they have cots and food for the engineers who are working on this,” he said. “They have produced a reliable and safe aircraft and as advanced as it is, they don’t want to put airplanes in the air with the problems we have seen.”
The government approved Boeing’s use of lithium-ion batteries to power some of the plane’s systems in 2007, but special conditions were imposed on the plane maker to ensure the batteries would not overheat or ignite. Government inspectors also approved Boeing’s testing plans for the batteries and were present when they were performed.
Even so, after the episode in Boston, the federal agency said it would review the 787’s design and manufacturing with a focus on the electrical systems and batteries. The agency also said it would review the certification process.
The 787 has more electrical systems than previous generations of airplanes. These systems operate hydraulic pumps, de-ice the wings, pressurize the cabin and handle other tasks. The plane also has electric brakes instead of hydraulic ones. To run these systems, the 787 has six generators with a capacity equivalent to the power needed by 400 homes.
This article has been revised to reflect the following correction:
Correction: January 19, 2013
An earlier version of this article misstated the response of regulators after small cracks were found in the wings of the Airbus A380, and the year those cracks were found. Regulators required inspections, followed by fixes; they did not order the plane grounded. And the discovery was made in 2012, not two years ago.
Boeing Closer to Answer on 787s, but Not to Getting Them Back in Air
This article
Boeing Closer to Answer on 787s, but Not to Getting Them Back in Air
can be opened in url
http://newsdiscarded.blogspot.com/2013/01/boeing-closer-to-answer-on-787s-but-not.html
Boeing Closer to Answer on 787s, but Not to Getting Them Back in Air
